乌龙茶品种鲜叶加工白茶过程中香气成分动态变化规律

陈林; 张应根; 陈键; 宋振硕; 项丽慧; 余文权; 尤志明

doi:10.13305/j.cnki.jts.2020.06.006

PDF(830 KB)

茶叶科学 ›› 2020, Vol. 40 ›› Issue (6) : 771-781. DOI: 10.13305/j.cnki.jts.2020.06.006

研究报告

乌龙茶品种鲜叶加工白茶过程中香气成分动态变化规律

陈林¹, 张应根¹, 陈键¹, 宋振硕¹, 项丽慧¹, 余文权^1,2,*, 尤志明^1,*

作者信息 +

Aroma Profiling of Fresh Leaves of Oolong Tea Cultivars during White Tea Processing

CHEN Lin¹, ZHANG Yinggen¹, CHEN Jian¹, SONG Zhenshuo¹, XIANG Lihui¹, YU Wenquan^1,2,*, YOU Zhiming^1,*

Author information +

文章历史 +

摘要

乌龙茶品种茶树鲜叶加工白茶具有明显的花香特征。为探明该原料在白茶加工过程中香气成分的形成与变化规律,在室内控温控湿（温度18~22℃,湿度45%~60%）环境条件下,选用福鼎大毫茶、福安大白茶和福云6号制成的传统白茶为对照,采用顶空固相微萃取法-气质联用法对茗科1号等10个适制乌龙茶品种鲜叶的萎凋在制品及其成品茶（简称花香白茶）进行了香气成分检测和化学计量分析。结果表明,花香白茶与传统白茶存在迥然不同的香气组成化学模式。各乌龙茶品种鲜叶加工的花香白茶及其在制品的香气组成化学模式具有较高相似度;随着鲜叶萎凋减重率的增加,其香气组成在主成分分析二维得分视图中的模式分布渐趋离散,并发生群体定向逐步偏移。聚类分析结果显示,花香白茶在加工过程中香气组成的动态变化与采制原料的品种特性密切相关。鲜叶萎凋减重率30%~60%为影响花香白茶香气品质形成的关键发展阶段,并以萎凋后期（减重率≥45%）对其在制品香气组成的影响最为突出。从乌龙茶品种试样中可检出的136种香气成分显著富集于3种变化趋势模型,其中芳樟醇及其氧化物、香叶醇、橙花醛、水杨酸甲酯、β-紫罗酮、二氢猕猴桃内酯等香气成分可视为花香白茶香气品质工艺耦合调控的主要化学评测指标。

Abstract

White teas processed from fresh leaves of oolong tea cultivars can be always detected with flower flavor characteristics. In order to investigate the formation and changes of aroma components during the manufacture of such fragrant white tea, fresh leaves harvested from 10 oolong tea cultivars including Mingke1 were respectively processed into white teas under controlled indoor air conditions set at 18-22℃ and humidity of 45%-60%. Compared with traditional white teas produced from Fudingdahao-cha, Fuandabai-cha and Fuyun 6, the aroma components of white teas and the WIP (work in process) samples prepared according to the weight loss rate of fresh leaves from oolong tea cultivars were isolated by head space solids-phase micro-extraction (HS-SPME) and determined by gas chromatography-mass spectrometry (GC-MS) in combination with stoichiometric analysis. The results show that there were very different chemical patterns of aroma components between fragrant white teas and traditional white teas. The aroma patterns of white teas and in-process products obtained from oolong tea cultivars were of high similarity. With the increase of the weight loss rate of fresh leaves, the distribution of these tea samples in the two-dimensional score plot obtained from principal component analysis tended to disperse gradually, resulting in oriented migration as a group. It could be seen that the dynamic changes of aroma components during the processing of fragrant white tea were also closely related to the properties of the raw materials from each tea cultivars by cluster analysis. From 30% to 60% of the weight loss rate was the key development stage affecting the formation of aroma quality of fragrant white tea, especially for the weight loss rate≥45%. The 136 aroma components detected in tea samples from oolong tea cultivars were significantly enriched in three changing trend models, including linalool and its oxide, geraniol, geranial, methyl salicylate, β-ionone and dihydroactinidiolide and some other volatile components with pleasant flavor, which can be regarded as the most important chemical indicators for the coupling process to regulate aroma quality of fragrant white tea.

导出引用

陈林, 张应根, 陈键, 宋振硕, 项丽慧, 余文权, 尤志明. 乌龙茶品种鲜叶加工白茶过程中香气成分动态变化规律[J]. 茶叶科学. 2020, 40(6): 771-781 https://doi.org/10.13305/j.cnki.jts.2020.06.006

CHEN Lin, ZHANG Yinggen, CHEN Jian, SONG Zhenshuo, XIANG Lihui, YU Wenquan, YOU Zhiming. Aroma Profiling of Fresh Leaves of Oolong Tea Cultivars during White Tea Processing[J]. Journal of Tea Science. 2020, 40(6): 771-781 https://doi.org/10.13305/j.cnki.jts.2020.06.006

中图分类号： S571.1 TS272.5+9

参考文献

[1] 梅宇, 梁晓. 2019年中国茶叶产销形势报告[J]. 茶世界, 2020(s1): 1-14.
Mei Y, Liang X. Report on China tea production and marketing situation in2019 [J]. Tea World, 2020(s1): 1-14.
[2] 欧阳明秋, 傅海峰, 朱晨, 等. 白茶保健功效研究进展[J]. 亚热带农业研究, 2019, 15(1): 66-72.
Ouyang M Q, Fu H F, Zhu C, et al.Research progress on health effects of white tea[J]. Subtropical Agriculture Research, 2019, 15(1): 66-72.
[3] Sanlier N, Atik İ, Atik A.A minireview of effects of white tea consumption on diseases[J]. Trends in Food Science & Technology, 2018, 82: 82-88.
[4] 李凤娟. 白茶的滋味、香气和加工工艺研究[D]. 杭州: 浙江大学, 2012.
Li F J.Studies on the taste, aroma and processing of white tea [D]. Hangzhou: Zhejiang University, 2012.
[5] 周有良. 萎凋、造型工艺对白茶化学成分含量及品质的影响[D]. 福州: 福建农林大学, 2010.
Zhou Y L.Effects of withering and shaping techniques on the chemistry and quality of white tea [D]. Fuzhou: Fujian Agriculture & Forestry University, 2010.
[6] 罗玲娜. 白茶连续化生产线及LED光质萎凋工艺与品质的研究[D]. 福州: 福建农林大学, 2015.
Luo L N.Studies on technology and quality of the white tea produced by continuous and cleaning producing line and the white tea withered by LED lights [D]. Fuzhou: Fujian Agriculture & Forestry University, 2015.
[7] 谷兆骐. 浙江省主栽茶树品种加工白茶的品质与工艺研究[D]. 杭州: 浙江大学, 2016.
Gu Z Q.Research on the quality and processing of white tea in Zhejiang Province [D]. Hangzhou: Zhejiang University, 2016.
[8] 陈林, 张应根, 项丽慧, 等. ‘茗科1号’等5个福建乌龙茶品种的白茶适制性鉴定[J]. 茶叶学报, 2019, 60(2): 64-68.
Chen L, Zhang Y G, Xiang L H, et al.Quality appraisal on white teas processed from Fujian oolong cultivars (Camellia sinensis)[J]. Acta Tea Sinica, 2019, 60(2): 64-68.
[9] 王丽丽, 宋振硕, 陈键, 等. 茶鲜叶萎凋过程中儿茶素和生物碱的动态变化规律[J]. 福建农业学报, 2015, 30(9): 856-862.
Wang L L, Song Z S, Chen J, et al.Changes on catechin and alkaloid contents in fresh tea leaves during withering[J]. Fujian Journal of Agricultural Sciences, 2015, 30(9): 856-862.
[10] 陈林, 余文权, 张应根, 等. 基于SDE和HS-SPME/GC-MS的乌龙茶香气组成特征分析[J]. 茶叶科学, 2019, 39(6): 692-704.
Chen L, Yu W Q, Zhang Y G, et al.Aroma profiling of oolong tea by SDE and HS-SPME in combination with GC-MS[J]. Journal of Tea Science, 2019, 39(6): 692-704.
[11] Bijlsma S, Bobeldijk I, Verheij E R, et al.Large-scale human metabolomics studies: a strategy for data (pre-) processing and validation[J]. Analytical Chemistry, 2006, 78(2): 567-574.
[12] 全国茶叶标准化技术委员会. 茶磨碎试样的制备及其干物质含量测定: GB/T 8303—2013[S]. 北京: 中国标准出版社, 2014.
National Technical Committee 339 on Tea of Standardization Administration of China. Tea-preparation of ground sample and determination of dry matter content: GB/T 8303—2013 [S]. Beijing: China Standard Press, 2014.
[13] 林杰, 陈莹, 施元旭, 等. 保留指数在茶叶挥发物鉴定中的应用及保留指数库的建立[J]. 茶叶科学, 2014, 34(3): 261-270.
Lin J, Chen Y, Shi Y X, et al.Application of retention index on volatile compound identification of tea and development of retention index database[J]. Journal of Tea Science, 2014, 34(3): 261-270.
[14] 胡西洲, 彭西甜, 周有祥, 等. 顶空固相微萃取-气相色谱/质谱法结合保留指数法测定龙井茶的香气成分[J]. 中国测试, 2017, 43(2): 55-59.
Hu X Z, Peng X T, Zhou Y X, et al.Determination of aroma components from Longjing tea by headspace solid phase micro-extraction and GC-MS combined with retention index[J]. China Measurement & Test, 2017, 43(2): 55-59.
[15] Chen Q C, Zhu Y, Dai W D, et al.Aroma formation and dynamic changes during white tea processing[J]. Food Chemistry, 2019, 274: 915-924.
[16] Ernst J, Bar-Joseph Z.STEM: a tool for the analysis of short time series gene expression data[J]. BMC Bioinformatics, 2006, 7: 191. doi: 10.1186/1471-2105-7-191.
[17] Ho C T, Zheng X, Li S.Tea aroma formation[J]. Food Science and Human Wellness, 2015, 4(1): 9-27.
[18] 陈维, 马成英, 王雯雯, 等. 萎凋时间对“英红九号”白茶香气的影响[J]. 食品科学, 2017, 38(18): 138-143.
Chen W, Ma C Y, Wang W W, et al.Effects of withering duration on the aroma profile of Yinghong No. 9 white tea[J]. Food Science, 2017, 38(18): 138-143.
[19] Wang Y, Zheng P C, Liu P P, et al.Novel insight into the role of withering process in characteristic flavor formation of teas using transcriptome analysis and metabolite profiling[J]. Food Chemistry, 2019, 272: 313-322.
[20] 陈勤操. 代谢组学联合蛋白组学解析白茶的品质形成机理[D]. 武汉: 华中农业大学, 2019.
Chen Q C.Study on formation mechanism of white tea characteristics based on metabolomics and proteomics analysis [D]. Wuhan: Huazhong Agricultural University, 2019.
[21] 郭丽, 郭雅玲, 廖泽明, 等. 中国白茶的香气成分研究进展[J]. 食品安全质量检测学报, 2015, 6(9): 3580-3586.
Guo L, Guo Y L, Liao Z M, et al.Research advance in aroma components of white tea[J]. Journal of Food Safety and Quality, 2015, 6(9): 3580-3586.
[22] 刘琳燕, 周子维, 邓慧莉, 等. 不同年份白茶的香气成分[J]. 福建农林大学学报(自然科学版), 2015, 44(1): 27-33.
Liu L Y, Zhou Z W, Deng H L, et al.Analysis of the aromatic components in white tea produced in different years[J]. Journal of Fujian Agriculture and Forestry University (Natural Science Edition), 2015, 44(1): 27-33.
[23] 俞少娟, 李鑫磊, 王婷婷, 等. 白茶香气及萎凋工艺对其形成影响的研究进展[J]. 茶叶通讯, 2015, 42(4): 14-18.
Yu S J, Li X L, Wang T T, et al.Research progress on white tea flavor and its withering processing[J]. Journal of Tea Communication, 2015, 42(4): 14-18.
[24] Pou K R J. A review of withering in the processing of black tea[J]. Journal of Biosystems Engineering, 2016, 41(4): 365-372.
[25] Dai W D, Xie D C, Lu M L, et al.Characterization of white tea metabolome: comparison against green and black tea by a nontargeted metabolomics approach[J]. Food Research International, 2017, 96: 40-45.
[26] Feng Z, Li Y, Li M, et al.Tea aroma formation from six model manufacturing processes[J]. Food Chemistry, 2019, 285: 347-354.
[27] Ning J M, Ding D, Song Y S, et al.Chemical constituents analysis of white tea of different qualities and different storage times[J]. European Food Research and Technology, 2016, 242(12): 2093-2104.
[28] Yang C, Hu Z Y, Lu M L, et al.Application of metabolomics profiling in the analysis of metabolites and taste quality in different subtypes of white tea[J]. Food Research International, 2018, 106: 909-919.
[29] Yue W J, Sun W J, Rao R S P, et al. Non-targeted metabolomics reveals distinct chemical compositions among different grades of Bai Mudan white tea[J]. Food Chemistry, 2019, 277: 289-297.
[30] Zhao F, Qiu X H, Ye N X, et al.Hydrophilic interaction liquid chromatography coupled with quadrupole-orbitrap ultra high resolution mass spectrometry to quantitate nucleobases, nucleosides, and nucleotides during white tea withering process[J]. Food Chemistry, 2018, 266: 343-349.
[31] Zhao F, Ye N X, Qiu X H, et al.Identification and comparison of oligopeptides during withering process of white tea by ultra-high pressure liquid chromatography coupled with quadrupole-orbitrap ultra-high resolution mass spectrometry[J]. Food Research International, 2019, 121: 825-834.
[32] 丁玎, 宁井铭, 张正竹, 等. 不同等级和储藏时间白茶香气组分差异性研究[J]. 安徽农业大学学报, 2016, 43(3): 337-344.
Ding D, Ning J M, Zhang Z Z, et al.Volatile compounds of white tea of different grades and different storage times[J]. Journal of Anhui Agricultural University, 2016, 43(3): 337-344.
[33] 陈志达, 温欣黎, 陈兴华, 等. 不同等级福鼎白茶香气成分研究[J]. 浙江大学学报(农业与生命科学版), 2019, 45(6): 715-722.
Chen Z D, Wen X L, Chen X H, et al.Research on aroma components in different grades of Fuding white tea[J]. Journal of Zhejiang University (Agriculture and Life Sciences), 2019, 45(6): 715-722.
[34] Qi D D, Miao A Q, Cao J X, et al.Study on the effects of rapid aging technology on the aroma quality of white tea using GC-MS combined with chemometrics: in comparison with natural aged and fresh white tea[J]. Food Chemistry, 2018, 265: 189-199.
[35] Zheng X Q, Li Q S, Xiang L P, et al.Recent advances in volatiles of teas[J]. Molecules, 2016, 21(3): 338. doi: 10.3390/molecules21030338.
[36] Yang Z Y, Baldermann S, Watanabe N.Recent studies of the volatile compounds in tea[J]. Food Research International, 2013, 53(2): 585-599.